I am writing to express my extreme disappointment with the recent failure of the original clutch/flywheel in the above referenced vehicle. The vehicle was purchased new from Mini of San Francisco on February 17, 2007 and all scheduled maintenance has been conducted in a timely manner including a recent scheduled maintenance on September 15, 2011 (Mini inspection), a mere seven weeks before complete clutch failure. No comments or suggestions were noted by the mechanic during this scheduled maintenance that clutch wear was occurring or should be monitored.The Mini Cooper was driven under extremely light driving conditions with an experienced manual transmission driver. The vehicle was typically only used for “motoring” trips on weekends. The previous manual transmissions driven were a 1986 Honda Civic DX (original owner 97,000 miles with one clutch replacement at 65,000) and a 1996 Honda Civic DX Hatchback (original owner with no clutch replacement as of 60,000 miles when car was donated). Furthermore, the driver was experienced in using the parking brake while resting on a hill to spare any unnecessary clutch wear. All maintenance has been performed by Mini of San Francisco and online service history is current per owners’ lounge website.The driver had never experienced a complete clutch failure with no prior warning signs. Furthermore, the driver had never seen a clutch fail under such light driving conditions so anticipated that it must be some sort of mechanical failure and immediately drove the vehicle to Mini of San Francisco. While the service department of Mini San Francisco provided excellent customer service, the driver conducted his own research into the situation while the mechanical review was being conducted and has noted that many other drivers of this vehicle have cited the same problem.The driver seeks a response from Mini USA on this very disappointing early clutch failure, the occurrence of this situation within the specific model, and the manufacturer’s guidance on extending the life of a clutch.

The car was bought used 2010 50K miles and about a yr later the trans took a dump. Class action lawsuit proved BMW America rushed the car to market with the design flaw. BMW America failed to tell the dealers they were selling cars to the consumers with a design flaw of the cvt trans. The 2nd trans failed 19K miles later. Irvine Mini replaced it again, waiting for the next failure. Class action forced BMW America to warranty the junk trans for 8Yrs. and 150K miles::)) Moral of the story Never buy BMW products again!!! Just bought TWO Toyota Prius-C models for my daughter to use at college and myself for work. 50MPG and loving it. GM same Junk. They sold us a 2014 Cruze with a recall and then said we dont have the axle to replace yours that has a crack. It met all three criteria for the forced buyback :) GM had the nerve to try and get us to eat 10K mileage deduct which would have been a 2K deduct in our monies returned. Dave ** in Mission Viejo, CA very good Lemon law Attorney.

I have less than 65,000 miles on my 2006 Mini Cooper Hatchback. I took it in for an oil change and my air conditioning stopped working. I was told the air conditioning was due to the compressor failing. So, $2000 later, I have air conditioning. However, on the repair order, I am also told that the strut mount ($645), Engine fan ($985) and some misc. things like a side axle seal ($347), crank sensor o-ring ($349) muffler bracket ($260) also need to be done.My question is, what is the muffler bracket made of for $260(?) and who has to replace a engine fan in less than 65,000 miles on a car? Ive driven some old vehicles and driven them for a long time but never had the engine fan go out. I cant believe after 6 years that my car should need almost $5000 worth of work! I should also mention they found the O2 sensor was out, again. This is the 3rd time that has had to be replaced. Thank God Mini gave me a lifetime warranty on that - but the dealership wanted $140 to diagnose that it was needed again.This is the 2nd incident I have had with the a/c - the last time it was leaking (thankfully while under warranty). Ive also had the thermostat replaced already. I feel uncertain that I can afford to drive this car another 2 years. The parts seem to go bad so fast I cant imagine what another 2 years will do to my wallet!

Purchased a Mini Cooper s new. After 32,000 miles engine started having major problems. Long list of repairs totalling $7,000 were needed. Sold car for a loss. I was sold on Minis styling, fuel economy, and small size. I wish I had paid attention to its lack of quality and longevity. I been driving for over 30 years and have never had a car with so many issues with such low miles. The service people and dealers seemed to imply my mini was some kind of unique problem. Guess theyve been drinking the Kool-Aid too long.

If you are thinking of purchasing or leasing a MINI Cooper, don’t. You would be dealing with a company that does not take responsibility for their franchisees, their employees, and their third party affiliates (ergo Roadside assistance). I was stranded in Yellowstone National Park for two days to no avail and had to turn to my insurance company. MINI then left me stranded in the Idaho Falls airport without a rental car. I am from Georgia. MINI is not taking responsibility for their negligence and an alignment that resulted in my tire’s uneven wear-and-tear and, ultimately, its ripping to the wire. You’re better off with another car/company. If BMW is anything like it’s daughter company, I wouldn’t go near them either. Save yourself an enormous headache down the road.

2015 Cooper 2-door hardtop - I was driving down a hill from my neighborhood and I braked to slow down. The brake pedal stuck midway to the floor and wouldnt stop. I had to use my emergency brake to stop. Once I let up on e-brake the brake pedal released. It is in the shop now.

The cars are garbage - trust what youre reading online because the issues are real. The dealers say well its a BMW - when your service bill is regularly $800-$4000. Well then I guess Volkswagen charges their customers PORSCHE repair rates? FIAT - Lamborghini? Turbo replacement - 70,000 miles = $4,000, clutch replacement 60,000 miles = $2,800 the whole front end of the car comes off, 2 water pumps & two tows!Car sucks oil like the Exxon Valdez 1qt every 1k miles at least and you have to check it ALL THE TIME. I havent had to do that since my first car in 1987 - which was built in the 70s!!!! RUN FLATS SUCK - harsh ride, costly to replace - TPSS sensors $199 each. Car engine clacks/rattles/ ticks/hesitates (turbo). Instrument cluster lighting - pixels go out. Third brake light - no longer working - $300 + labor. Convertible top wear (rubbing the mechanism) dealer says outside influence/tear - but it ISNT MINI Corporate doesnt want to hear it - doesnt acknowledge anything let alone work with you.The good things are its a good looking car, fun to drive but not near enough to offset the horrific expenses to keep it maintained and fix the amazing amount of problems that come up. Like others in the forum say - MINI Corporate considers everything to be your problem - too bad, so sad - next customer please. Well not me. Cant wait to get rid of it.

I bought a 2010 Clubman S in December of 2009. Since the beginning, there have been lots of problems: tons of rattles inside, the windows stopped working twice, the A/C made a huge whining sound, there are clunks from the engine area that no one can figure out where they are coming from, the check engine light came on randomly twice and the car went into limp mode (at the dealer nothing wrong was found), pieces of outside trim were installed poorly, the sunroof wont open on hot days without pushing it with your hand, the brakes sometimes feel shaky when making sudden stops (not ABS, or if it is then its the worst ABS Ive ever experienced) and the inside of one of the club doors popped off.This car is made incredibly cheaply, and the problems I have had are echoed by some other Mini owners Ive met and all over Mini message boards. I spent $32,000 on a poorly made piece of junk, awesome! Both Nick ** and South Bay Mini have not taken responsibility for some of the problems, sometimes saying things like, Well, the MINI is a quirky car. If quirky means made like junk, then yes, theyre right.To top it off: the handling is downright dangerous because of the torque and bump steer.Fun to drive but made horribly, and way over-priced for the quality you get.

We bought our 2009 Mini Cooper new, and enjoyed it for the first 20,000 miles, or so. Problems so far are: 3 trips for Oxygen sensor. Fixed on the third trip when I suggested the Pennsylvania Lemon Law, gave the dealer three attempts to repair. The next: Aluminum brake rotor replacement. Who knew that a complete four-wheel brake job would run over $2,200?! Then: At 47,000 miles, water pump needed replacement ($900.). Now, at about 48,000, we have a transmission shifting hesitation and lurching. Happy Motoring is being an oxymoron. Oh yeah, the passenger window would go down on its own, like a ghost operated it. It took dealership over 3 hours hooked to a computer to upgrade the software.

Oh boy!!! I wished I would have read some of the reviews before buying into this 2012 Mini Countryman S from a CarMax dealer in GA with 26k miles, automatic, that is currently at the dealership for a shift assembly repair. Bought the car with warranty still in place. Without warning, car would not get out of park, had to be towed in. Dealer took a few days to diagnosed that a leak was found that came from the drink cup holder that leaked down into the shift assembly, and considered it was due to what they call misuse. Now I dont know about everyone else, but I thought drink holders were made to hold drinks??? Well duh! Not on these Minis!!! An 1,800 out-of-pocket repair. I dont think anyone would purposely pour a drink into the cup holder but I think accidents can happen. It is very concerning for me because I have to pay for this car for several years and was thinking about purchasing the extended warranty for coverage while still paying for this car. Based on the reviews Ive read, I scared of whats to come next. Ive never owned a car to be totally disabled on me and cost me for repairs while under warranty for major problems. I really think that Mini/BMW or whomever needs to take a look at their warranty. After all, a car doesnt just need oil and water maintenance! I feel stuck and afraid of whats next. As far as Im concerned, they should just remove all the drink holders or caution or let customers know its just there for show and not to hold cups with liquids in them!!!!!!

I was hesitant to buy in first place. I bought new. It was a cheesy car. Everything was fragile. Window switches, seat belt labels, transmission shift mechanism, plastic trim, oh well. But its had four (4) different turbos at $3,500 each. Its had a number of service bulletins/campaigns/recalls depending on what persons or entity you talk to. One turbo was under warranty, the rest were not. But then BMW Mini rebates the $3,500. A different recall changed some turbo related part. The day after I picked the Countryman up, it wouldnt start; Dead battery. I just put my charger on it. Started fine. The service advisor suggested probably drained while in shop. The battery was relatively new. It needed to be jumped or charged 5-6 times in next few months. Then I found out that the recall, service campaign or whatever resulted in electrical consumption after shutting off engine hence the battery drain. Now I need a new battery; $300. INSANE. New FRONT brakes $700.00. REPAIR LEAK AT OIL FILTER MOUNTING FLANGE $1,300. I have owned a number of vehicles including Yugo, Smart, Mercedes, Porsche, THIS IS MY BIGGEST MISTAKE! My local dealer is immune to any logical argument about what is wrong or more importantly how it came to be so. Shame on them. The service costs are pathetically high- its not a Porsche, performance is mediocre. I believe in drive like a sport, pay like a sport. But this isnt that sporty. Next car; Toyota!

I leased a brand new Mini Cooper Countryman S only 6 months ago. Everything has been great until recently. I was three hours into a 5 hour drive when suddenly a red light came on telling me to stop and shut off the car since the engine was overheating. I immediately called my salesperson who said to use the SoS in the car to get a tow. I was told to not drive for car. Unfortunately, I was on the side of I-95 where 18 wheelers were flying past. Well, I sat there for 3 hours, THREE hours, waiting for my tow that Mini organized. It was terrifying to say the least.It was towed back to Alexandria, Va where I live and leased the car. I was informed that a stone hit underneath and damaged the radiator and that I had to pay for it. What? How could that be? My drive was smooth and nice - no problems. I have since discovered that is a design flaw that exposes the radiator to this type of damage. I had to get my insurance co involved, and I have been waiting two weeks already since a needed part is coming from Germany and they have no idea when it will arrive. I have been car-less except for the first several days when Mini gave me a loaner. After all of my complaining, they have since said theyd give me another loaner which I will pick up shortly. First of all, this is a lease, and this is a corporate problem so I should not be responsible. Secondly, if my leased car sits in their garage for a month (?), why should I make a payment when I dont even have the car. Needless to say, I am dumping this car after my lease, and I am not leasing or buying another Mini Cooper.

I was in 2 accidents a month apart (Its not my fault.) in my 2007 Mini Cooper. So, I sent it to my local Mini dealer, thinking they knew what they were doing. When I had a warranty, I got excellent service, but not after my warranty was up! They broke things on the car, lost pieces, put things in backwards - it was a nightmare. I was told that all those things were wear and tear. It happened in the accidents; it was fine before. They would not fix the things they broke, and they were just so rude, saying I was making it up! Im not! So, they told my insurance company that its like that before the accidents. So now, they closed the claim and would not fix the problems. Problem is, they broke the parts or did not fix it right. They would not say they did it and made it right. They were very sobbing, and they think they are some great fancy place, not just another car repair shop. And in my accident, I broke my nose on the steering wheel. The air bag did not go off and the seat belt did not hold me back! I was slammed hard from behind. The problem is the dealership.

I am writing because I am shocked at the terrible reviews I just read. I have owned my 2005 Mini Cooper Convertible since November 2005 and have never had a single problem. Of course some of that may be due to the amount of miles I have on it (about 38,000). We drive it from N.C. to Fl and return once yearly. Although there are only a few miles, the main thought I have is, why havent I had any problems in the 12 years I have owned it? Anyway just want to share my good news after reading the previous ones.

I bought a 2003 Mini Cooper new and it had been a great car up until 70,000 miles. The automatic locks stopped working, the car would overheat when idling, but the biggest issue is the transmission went and I was told it would cost approximately $8,300 to replace. This is just wrong to have a transmission go at 70,000 miles. From what I have read this is a common occurrence. I was expecting a decent trade in value but now my car is worthless. Im very disappointed. The only reason I gave 3 stars is because I did enjoy the car for the time I was able to drive it.

Bought a used 2007 Mini Cooper r56 S model for general use. Was in nice shape, good Carfax, low miles (54000) and not even 30 miles down the road in the middle of a four lane highway, the car shut down completely. Had the vehicle towed home and then to Mini only to find that a vacuum pump went out while driving. Gave no warning which led to seizure of the engine. Mini has quoted almost $8000 in repairs and, after calling corporate, they are refusing to assist in any way, shape or form. This is a well known problem and I am shocked that they are continuing to allow this to happen with no resolve. My extended warranty doesnt cover vacuum pumps so no help there either. Just a terrible situation. I hope that someone engages a class action suit against Mini for these problems. Not only did it destroy me financially, it almost cost me my life as no warnings, bells, etc. went off and the vehicle left me in the middle of four lanes of traffic. Mini North America offered NO help, so now I will continue to write others and warn people not to buy these vehicles as they are dangerous.

If I could give negative stars, I would. After owning this car barely 4 years, and JUST as the warranty expired, the engine pulley had to be replaced. Lights came on Battery Malfunction Engine Overheated- turn off car, do not drive, etc. Mini changed how they made this part in 2016 but have failed to recall it in this model. They only recalled the S Cooper. In spite of this part being a problem, they refuse to reimburse car owners for the very expensive repairs. Courtney from Mini USA called to give me her speech on this not being a known problem, even though they changed how they made it the next year. She also said it was too bad for me since I agreed to pay the service department for the repairs. I told her I was stranded at the grocery store when the lights came on and had to have it towed to the dealer. Was I supposed to walk to work? She said the warranty expired and I shouldve bought the extended warranty at purchase. I said the car shouldve lasted more than 4 years without an engine issue! Obviously, BMW USA AND MINI USA couldnt care less about standing behind their cars once they have your money. Your only recourse is to spend more money for when they break down. IF I CAN GET RID OF THIS LEMON, I WILL NEVER BUY ANOTHER MINI EVER!!!

I bought a used 2002 Mini Cooper Hardtop a couple of years ago with 72,000 miles on it. It was the first car I ever bought and I got a loan on it. A couple thousand miles later the CVT transmission blew. $4,000-$5,000 fix. And that isnt the only thing that went wrong with this car. Dont buy a Mini or anything from BMW. They dont stand behind their products.

I had to replace the crankshaft pulley assembly and serpentine belt at 51,909 miles. The age of the car at this time was roughly 5 years and 8 1/2 months.The headliner has started falling. This started at around 53,000 miles in January of 2011. The age of the car at this time was roughly 5 years and 10 months. This car has been garaged for most of its life. I have had cars for much longer than this and these type of problems do not seem normal for the mileage or age of the car.

2009 Mini Cooper S Convertible - I havent even had this car one year - the turbo has been replaced and now the check engine light wont go off and they are saying it is carbon build up... but the In Drive that I utilize with State Farm says Power Train failure.

Updated on 03/26/2019: The last time I posted my Mini was in the shop (at 55k) having the head gasket replaced. 8k later the head gasket had to be replaced again. The shop wanted to re-check the car 500 miles after the repair, which they did, and all was well. Decided as soon as the first sunny, reasonably warm day came I was going to clean/wax the car and get rid of it. The other day fit the bill so I went to the auto parts store to buy wax, etc. Got out of the car and noticed the fan was running. Managed to make it back home without any lights coming on, but the fan continued to run. 10 minutes later I went to start it to move it a few feet in the driveway and the engine light came on and the car didnt want to start. The car just turned 65k and has always been maintained. We have mechanical breakdown coverage through our insurance and frankly Im hoping the entire engine is bad and we can just get whatever they give us for it and be done with it. Absolutely a blast to drive --- but from a mechanical standpoint its far and above THE worst car Ive ever owned.Original Review: Although my 2012 (hardtop) Mini is a blast to drive I will NEVER buy another one. Just turned 55k miles and Ive already had to replace tires/rotors, ignition coils, and the water pump. It is currently in the shop with head gasket/engine repairs to the tune of $2,500.00. Thank goodness for the mechanical breakdown coverage we opted to buy when we bought the new Mini! Its absurd to have this many expensive repairs on a car with only 55k miles!!

I know I am going to get bashed for posting this but understand the only reason is to let Mini customers know that repairs they are paying for at Mini Georgian or after talking to Mini Canada may have been a warranty repair. Georgian Mini Cooper in Barrie tried charging customers for work that should be covered under warranty. This happened twice to me. Once for rust repairs and just recently for a power steering pump at a cost of $1600 plus tax. I had the power steering pump replaced under warranty at Mini Vaughan with no issues. What is strange is I have a email from Mini Georgian in Barrie saying my car has no warranty/recall for power steering pump and a second email from Vaughan Mini stating that yes, the power steering pump is covered under warranty.SO BE VERY CAREFUL DEALING WITH MINI GEORGIAN IN BARRIE or information from Kelly at the head office for Mini Cooper Canada AS THEY DO NOT CARE ABOUT THEIR CUSTOMERS AND ONLY CARE HOW MUCH THEY CAN CHARGE YOU. IF you had a power steering pump replaced at Mini Georgian or anywhere else, you should call Mini Vaughan to verify that it is not on the warranty recall. My car is 8 years old and was covered.See below correspondence with BMW CEO Mr. Reithofer email (**):#1 - I regretfully having to contact you again regarding the service I have encountered by my closest Mini Cooper dealer (Georgian Mini) in Barrie Ontario, Canada. As stated in prior emails, I am a true and true Mini Cooper owner and am a lifetime owner hopefully. Mini Georgian is trying I feel very hard for me not to continue owning future Mini Coopers as I just had to AGAIN travel 360 Kilometers (90 Km each way 180 x 2 days) to have my Mini Cooper serviced at your Vaughan Mini location in Woodbridge, Ontario instead of my local Mini Georgian dealer that is about 4 km. away.Mr. Reithofer, this all started when I was having issues with my power steering on my Mini Cooper and did a little research (Google) on Mini Cooper power steering problems. I noticed that my car might be covered under 150,000 or 10-year warranty. I phoned and asked Georgian Mini if my car was under warranty for the power steering pump and was told as you can see in the attached email from the dealership that no warranty left on your vehicle and it does not have any recalls regarding this issue.Mr. Reithofer, just because of past dealing with Mini Georgian regarding warranties or recalls as they just seem not to care about their customers only how much can they make off of them, I contacted Vaughan Mini Cooper to inquire with them. After talking with Ashley at Mini Vaughan, she advised me without me saying anything about warranty/recalls that if the problem is the power steering pump then it will be covered by warranty and if it is only a leak then it would be my cost. Please see attached email from Mini Vaughan.So, Mr. Reithofer, why do I have to travel 360 Km. over two days (Mini Vaughan did not have power steering pump in stock) to have my car serviced under warranty when I contacted Mini Georgian who has the same info on my vehicle as Mini Vaughan does but advise me that the power steering pump is not covered. If I did not follow up with Mini Vaughan, it would have cost me approx. $1600 plus tax to replace a part that is under warranty. How many other customers have been taken advantage of by Mini Georgian in this manner? As of now, I am afraid to take my Mini Cooper to Georgian Mini for so much as a oil change as all they seem to care about is how much they can make off me bringing my car in and no regards to how to treat a customer.#2 - I just received a call from your Canadian office by a rep named Kelly. She informed me that there is no recall to the power steering pump. She started out stating that we have talked before and that she had talked to me about previous complaints (previous rusting issue covered by Minis 10-year rust protection) indicating that I am a constant complainer. Kelly was under the understanding that the power steering pump would not be covered as it does not have a warranty under my vin!!!!!!I asked if she even read my concern and she said yes. When I mentioned that the pump was already replaced, she quickly backtracked on what she said to me. I ask her then why in my letter did I mention I had to travel over 360 km to have my power steering pump repaired, She advised me, I thought you drove down for two days to have a consultation regarding it being covered by warranty!!!!!!!!! You have to be kidding me that someone would do that and it indicates to me that she just figures I am a difficult customer and I would do something ridiculous like this. So your senior employee dealing with customers with the already perception that they are wrong and she seems to take pride in being right and letting me know that. She was 100% percent wrong telling me that it will not be covered under warranty and as stated was shocked to know it was already done. So how much did she look into my concern before she called me?Again, my original questions were not answered as Kelly was too quick to just verbally attack me telling me that she dealt with me on previous complaints and that this concern regarding the power steering pump I was wrong also and as in her words it will not be covered by warranty. I dont like the word complaint as it is more of a concern. I guess Mini Canada Reps calling them complaints are all on the defensive and not dealing with customers concerns in a bias manner.I am so frustrated by this treatment I could just sell my Mini as I do not want to have dealings like this every time. But on the other hand that is silly talk as I love my Mini and I guess the relationship now is a abusive one. Every time I deal with Mini, I get treated poorly and I keep coming back for more. So it is my fault for coming back every time but I love my Mini too much not to. All this just makes me sick to my stomach in how I am treated every time. Awaiting your response and please do not hesitate to contact me should you need further clarification on any manner.Again you can bash me but all I want to do is give Mini owners a heads up when dealing with Mini Georgian in Barrie as they may pay for work that should be covered by warranty. Hopefully, if you have had work done, you can get your money back.

First I have to say it is a fun car to drive, love the looks but... I bought this car with 60,000 plus miles, and I purchased the platinum warranty because I never owned a turbo. Glad I did. Other than the car driving nicely, it turns out this engine needs a quart of synthetic oil every 800-1000 miles. Kind of expensive when you need to put Castrol synthetic at $9 a quart. They changed several oil lines, valve cover and gasket, a leaking solenoid, and the turbo. Now I must say the service experience is not bad, but it seems they are fishing. After the turbo replacement and valve cover replacement, I thought that would have fixed the problem. A week after I got it back, I am paranoid about losing oil. Lo and behold, it’s already low on the dipstick by an 1/8 of a quart. So guess I’m taking it back... Now the service guys at Mini do tell me that this is common for this engine to use that much oil. Sorry that’s a cop out for a bad design by Mini or shall I say BMW. Never in a million years would I have thought this was losing oil, but one day I turned into a store, and my oil light flashed. I stopped immediately and checked the oil which the level never registered on the dipstick. That’s how I found out. After that due to the low oil, I had carbon build up on valves, which caused it not to start one day. Other than a fun car, all I can think about how many people had to replace an engine due to an engine failure due to no oil??? One test they wanted me to do was bring it in so they could top off the oil, then drive it for 1000 miles to see if I was losing oil. I lost about 3/4 of a quart and that’s when I found out I needed a new turbo and valve cover.I think Mini needs to step up and fix this problem! It must be a poor design. I am seriously thinking of selling this car and would never buy another if I have to put more money into it. Unfortunately the fun factor goes out the window when you have to keep putting money into it to fix it. I can only speak of my experience so far. But after reading other reviews of this car... not sure I should have purchased one. Could have gotten the experience if only I could have rented one. You live you learn. BMW should stand up and do the right thing... from what I can tell due to their poor designs it creates a lot of problems and angst for their customers. Step up Mini and BMW and do the right thing!

Im an original owner of a 2008 Mini Cooper Clubman out of warranty. I took the car into a repair place because the engine light was on. It was diagnosed with a bad turbo, even though I changed the oil every 5-7K with the designated synthetic oil. This was a hard pill to swallow at $3400.00 but it was the best option considering I owe 17K on the car and its only worth 17K with a good turbo. So I said okay on the repair. The shop called me on the day it was supposed to be done and said they had bad news. When they went to get the car started, the timing belt busted when it turned over and the engine is toast and needs to be replaced. So, any ideas out there? Ive read about peeps with issues in the turbo and the timing belt.

We absolutely love our late 2017 Mini Countryman Cooper S ALL4, reliable, sporty and fun to drive. However, the radiator design is flawed and prone to damage by rocks that can enter via the large grill opening in the bumper. The design is such that the cooling fins of the radiator are located between the cooling pipes whereas most cars the cooling fins also go in front of the radiator. The issues is when a rock enters, it can pierce a hole in the exposed cooling pipes (the vertical lines either side of the cooling fins) rather than the fins absorbing the impact of a stone as they do on more traditional radiators. Though it is a design flaw, it is not under warranty as is is caused by general wear and tear and not a manufacturing or assembly fault. CAD ~$300 parts and ~$400 labor plus tax made it a bill of CAD $900 to replace the radiator.

I bought my Mini from the dealer - the owners daughter had driven it for 11k km. I got an extended warranty 160k and then it took two weeks to get delivery because the electronics in the car wouldnt allow it to pass emissions. Since then I have put 90k but have been through hell with the electronics telling the car the brakes were worn out 3 times but they werent, sometimes it wouldnt start, the CD player quits all the time, the air bag light comes on all the time etc etc. Its endless to write it all. The dealer each time says They cant replicate this condition and reset the computer. We can land on the moon but cant fix a Mini. Stay as far away from a BMW Mini as you can. Great car to drive - just too many problems and nobody that can fix them.

The car is scheduled for yearly oil changes. Because it was 2000 miles over the oil change time when it was changed, they refused to honor the new car warranty. I could not believe it and went to corporate, to no avail. The turbo went out and they refused to fix it on a 35K mile car purchased new from them.

Love the car although its not as reliable as Toyota. But then, you dont buy a Mini if youre shopping for Toyotas. Ive had some issues with bad battery connections and the cap on my emergency break has been broken since I got it. I will day that Ive left it parked for up to 3 months and it started up just fine.

Purchased a new 2004 MC hatch, only minimal issues until 2007 while still in warranty, the car slowed until full stop on the busy highway intersection. We were literally put in the danger since the traffic was heavy, and car could not be even started or moved. Towed to the local dealership, they changed transmission fluid, and we were assured the engine was checked and re-checked and driven miles, all is fine. It was for a while although experienced problems with automatic window and two other engine issues, but no lights went on and the dealership claimed this sometimes happens and not to worry. Once off the warranty, the same stop on the highway, overheated engine, stopped, towed back to the dealership and this time (although explained that the scenario was exactly the same and sanctioned by them as fine before), now the Cooper has a major issue and we need to pay around $8,000 for replacing CVT transmission. We were fortunate that on either occasion nothing happened to either us or the drivers in the traffic around us. MINI/BMW would not even listen -the only fix is to replace the CVT transmission.Took the car to an independent Euro repair-shop that did confirm that CVT is not properly working, but we also learned that MINI has known about this issue for years and this is far from individual problem. In fact, there are many complaints and pending class-action lawsuit related to this issue. Our MC with little over 40,00 mileage and after always being maintained and properly checked, has been sitting in the garage and would not drive it beyond a very short distance around the block. Other issues: faulty wheel, had to replace battery prematurely, CV player stuck, front seat unable to move, and the list could go on. We are the first owners, always driven by two family drivers with good experience, yet have never owned a car with so many problems, and excessive charges for any minute repairs. Will join any nationwide class-action lawsuit if available. Owned European cars before, but this one was built with faulty CVT transmission and BMW knew about it although they keep insisting this is a problem they havent heard about before? I doubt it. It is all over their website, even non BMW dealerships are well aware if this. How is it possible that BMW would not stand behind their product, this is not understandable. We hope that MINI/BMW would be forced to pay for CVT faulty transmissions they put into these cars and while they reject any assistance with repairs, we hope that class action lawsuit would justify the owners big expenses or those who have cars standing around and could not drive them. Shame on this company.

My Mini C S convertible is under 100k miles and took it to change oil. The mechanic says it run a diagnosis and diagnosed it need a new transmission and cost over $8000. I still owe on this car 5 more years. What is the thing to do now? This is the scariest thing ever. Now the car is lurching and light is on saying needs service. Where am I to get the 8k to fix? I heard a lot of people just leave and abandon this cars but did not know the experience until now. I am debating if I should take it to the Car Experts in Glendora, CA where they rebuilt for $3500. I am over 100 miles from them and really have no money now. I need my car so bad to go to school and work.

Our engine light came on on our 09 Mini with only 18000 miles on it. Took it to the dealer and they told us that there was excessive carbon build up on the intake valves and it would cost $1000 to grind the valves! I asked why this happened to a new Mini with such low mileage on it and was then asked what gas we used. We use Costco Premium almost all the time and then we were told that this is the problem. They said Costco gas was poor quality gas, it caused the problem! What BS!!! Its poor quality engine! We are also seeing other people having this same problem, so it is just not us. Mini should stand behind this problem!

I purchased my 2008 Mini Cooper S hatchback with 32K miles on it and still owe $11K. I quizzed the salesperson on maintenance requirements and different aspects of the vehicle; so far nothing he said has been true and I have spent $11K so far in repairs. This car, with payment, gas, repairs and insurance is costing me $880/Mo; a house payment for heavens sake!Right now it is in the shop after: 1 month ago replacing the valve cover ($800). 2 weeks later the timing chain ($4K). Not even 2 weeks went by and now waiting for the call to find out what the current issue is but know its going to be big $$ because the engine light went on again. I purchased this vehicle for the gas mileage as I have a 56 mi commute to work and its a BLAST to drive but the most UNRELIABLE & DANGEROUS car I have ever owned! Im probably going to sell it to the dealer and take a huge loss with nothing to show for it. Minis are like boats; the 2 happiest days of ownership are when you buy it and sell it! Youve been given fair warning: Dont buy a Mini!

I got my Mini used in 2008. Two years after, my alternator went. A month after that, gas pump and brakes followed and then a couple of months, transmission went quoting me $6,000 to $8,000 to fix it. My car has been parked for almost two years while I am still paying for it. Its not even worth fixing because it cost either more or the same amount as I was to buy another used 04 right at this moment. This car only has 89000 miles. My purchase price was $13,800 plus tax plus about $3,500 in repairs before the transmission went. If I fix that, another $6,000 to $8,000 more. Hmmm, over $26,000! Insane. Im not even sure what to do with it anymore. I have put so much money in it that even if I get rid of it, it would be pretty much for free because I would never get that money back! You pay for Macys prices and get Wal-Mart material.

My automatic 2006 Mini Cooper with full option had many different problems from the beginning (e.g. A/C hose broke at week 1). But the transmission problem is really what angers me and makes me want to start thinking about legal steps. My car is 4 years and 7 months old with 75,000 miles yet the transmission is already broken. I still havent paid off my car at this point and they are saying that the car is only worth $3,500. I guess they know Mini is **.

It is 2 years and 2 months I have a new Mini Cooper S coupe and it is full of problems. Started with overheating issues which took 3 multiple day visit to the dealership to finally get the right fix. The issue was documented by multiple technical bulletins which referred to 3 fixes overwriting each other. However bmw was only addressing one bulletin at a time, making the problem an ongoing issue. Another problem is the smell of unburnt gas when I start in hot weather. Bmw never been able to resolve this, telling me there is no problem. This is my 3rd Mini and I know that something is wrong there with this one. Finally, now it is the radio that keep playing even if I press the power button, turn off the engine, remove the key or lock the door. I had to remove the fuse to stop it. Now I will have to spend more personal time at the dealership to get this fixed.The car is now close to be off warranty because of the mileage, and it seems that problems are far to be terminated, cause huge inconvenience and soon huge cost to resolve out of warranty issues. Any problem discovered during the warranty period should have extended coverage so bmw would be forced to fix issues and not wait the end of warranty to charge the client.

I have a 2009 Mini Cooper S with 58,000. I drive the car daily. Recently a oil drip started to appear in the garage. I take the Mini to dealership (they are the only ones I take this car too) and they tell me I need to replace the gasket for $1,800.00. I am also told - that this is a common issue and 1-3 are seen each month for the same work. I am told the cause of the gasket failure is the engine goes from cold to hot and then back to cold. I asked like normal drive - from the house to the office then back home 9 hours later - I was told yes. Upon further reading and investigation - the issue is not the gasket but the housing becomes warp over time - due to poor design - no bolts to attach the oil housing to the oil coolant - thus a heat warp is created and oil starts to leak out. So, even if I pay $1,800.00 for the gasket repair - the warped housing is not corrected and the oil leaking will start over again. If Mini is aware and so many are being seen each month - why not a recall and a corrective fix.

My 2007 Mini Use 1 quart oil every 3 week! After 60,000 miles. My dealer told me that is normal. I do not think so.

I have a 2005 Mini Cooper convertible. I love my car, but now she is costing me a fortune. First, the power steering pump went out and I had to replace that at $1,100 (that was going to a certified Mini mechanic, but not the dealer). Since this is a problem with Minis, why is there not a recall? Now, I am having problems with my convertible top, (also a problem with Minis). The dealer wants over $800 for the parts and $520 for labor. But they only want to warranty it for 2 years. So I have found someone who specializes in convertible tops and is doing the work for half the price.There are other things that I am having to replace all at once. But my issue is, Mini has recognized most of these things being an issue in just about all Minis and refuse to recall these items. I bought my car used, because I saw what other Mini owners were complaining about and I was not about to buy a new Mini and have to always go to the dealer for repairs. This will most likely be my first and only Mini unless something is done. I love my car, but this is getting to be ridiculous and with the price of gas going up and our economy coming down, you would think that Mini would start taking some responsibility.

BMW Corporation were rude and wanted no responsibility once you bought the car, if things went wrong. Now experiencing a steering and fan pump issue and was never informed of their extended warranty offered and Im very disappointed once again in the company. The company has put my life in danger by not informing me of this imperative and vital information!

Mini Cooper S 2010 problems -- I got this car from my niece with only 17000 miles on it. Since then, my car has spent a lot of time on local dealership. I had to replace following things: Faulty High Pressure fuel pump, Torx Bolt, Pressure hose assembly, Turbo heat shield, stabilizer link, steering box, brake pads and sensors, vibration absorber, Timing chain tensioner leaking, aux water pump. They also serviced my car for carbon build up in the intake valve. Well this was done in last one year. Last week my car stopped at the freeway and I had to get it towed to Mini Dealer in Gaithersburg, MD. They told me that it has missed the timing which could be due to slipping timing belt or loose timing belt tensioner. I am waiting for this phone call and heavy bill they are going to tell me about. Since the car is just out of extended warranty with 27000 miles and little over 4 years, MINI will not cover the repairs.

I bought a beautiful brand new 2012 Convertible Mini Cooper, and sold it after 1 year and 20,000 miles. I got rid of the problem car. I refused to listen to my friends who suggested to me to buy anything but a BMW product because it is overrated. I could forget about the inconvenience of having only 2 front seats, because the 2 back seats are useless, they are very uncomfortable, feeling as if you are seating on a rock, my 5- and 2-year-old kids refuse to sit on the back seats.The car is poorly designed. You have to reach far away and over the top to reach the window controls, sunroof and lights. I had to buy myself an air compressor, to pressure the tires, because the stupid tire pressure sensing valves will leak air all the time. I bought a convertible car to be able to open the top as I please, but frequently, anything on the trunk will trigger a stupid switch, that will prevent the top from opening. My little Mini used fuel as if it was one of those Lincoln Continental of the 60s. I bought a Mini without Turbo Charger, but it is a gas guzzler. They claim the car makes 37 miles a gallon on the highway. The best it can do is 25 mpg. The car has a massive 14 gallons of fuel and for a good reason, it uses a lot of gas.To be objective, I can only cite one or two good things about this car. As small as it is, it has a rough ride. It feels as a go-cart ride, but it takes the road curves really good. This car is a city car; it was not made to ride for longer than 2 hours. If you have back problems, they will worsen with this Mini problem. The other advantage is that for a convertible car, it is quiet. You can have a conversation and listen to classical music.I do not recommend this car if you like the comforts of being in the city. Please do not buy a problem. The customer service is horrible. When you are buying the car, they offer you free 36,000 miles maintenance. They ripped me off - I had for brakes after 15,000 miles, and it was not cheap, because BMW cars do not replace pads. They replace rotors, packing, pads and bearings - $500 brake job. The worst part of the nightmare was the overheating problem. The car has been poorly designed with a bad cooling system. It provides weak air conditioning. If it is freezing, the hot air reaches you after 15 to 20 minutes. In a hot day, the air conditioning is worthless, and on top of that, after 20,000 miles, the stupid car developed overheating problems. I took it to the dealer and they did not want to even answer the phone. I took the car 2 times complaining about overheating, and they could not fix the problem. Instead of doing the lemon law frustration, I just sold the car and gave the problem to another fool. I do not recommend Mini Cooper. It is the worst investment you can make.

The fan kicked in the day I bought it in 2009, just after leaving dealer. Little did I know, it was in need of servicing then. $4,300 in repairs in under a year and still the vehicle overheats. Fan, water pump, thermostat, reservoir tank, all were done and now its going to be serviced yet again at local Mini dealer. They say the parts are warrantied but what part fails after eight months of regular use? The closest repairs are two hours away. I continue to rely on my insurance towing to get the car to be serviced as the vehicle will not make it there safely.I cannot recommend this brand to any one walking on a Mini lot nor can I express a positive remark about my experiences to family or friends. BMW should listen to all of the blog entries and issue a manufacturers recall on the entire line up. Faulty fans, transmissions and water pumps isnt enough to convince you to shop elsewhere? Then try your luck but there are plenty of warnings. A lot of disgruntled customers blogs had been available prior to my purchase. Had I read any of them, I would have steered away in a more reliable vehicle.

Let me start by saying my vehicle is a 2007 MINI Cooper S. It currently has 114k miles on it. The original owner had purchased a 100k mile maintenance package so all service was completed by MINI at the recommended intervals. This car was taken care of and babied. My vehicle suffered a complete engine failure on 12/2012 at around 105k miles. The failure was caused by the poor design of a lifetime part. I received an undated letter sometime a few months ago where MINI admits that the part that failed on my vehicle was, fitted with a faulty chain tensioner which may lead to an insufficiently tightened timing chain. A loose timing chain is recipe for disaster as this is what keeps the pistons and everything moving in the correct timing and order. When this chain breaks or skips a link it can cause devastating damage which it did.I contacted MINI in hopes of getting some of my $6500 that I paid for a replacement engine reimbursed. After being put with a customer relations supervisor name Shawn who didnt return any of my messages for 3 weeks, he finally calls me back and states that my claim was denied. But when I asked for a reason, he wasnt able to give me one. I asked to speak to a supervisor to which he stated he was the supervisor and nobody would be able to give me another answer. Ive sent off various emails, most of which are ignored, and various calls which seem to get me nowhere. MINI has 100% admitted fault for the damage to my engine but they wont take financial responsibility for their design failure. It has put me behind financially and causes me to lose faith in a company I trusted. I have all paperwork to support my claims and wish to get them to own up to their failures.

I have to start by saying that the Mini of Fairfield County in Stamford has been great about dealing with my 09 Clubman. I purchased this car as a post cancer treat to myself, trading in a 95 Mazda MX6 that had not given me a lick of trouble for the 14 years I owned it. It drives great, is a lot of fun, and hauls an awful lot of stuff! I do wish I got a turbo, but perhaps I would regret the tickets I would have invariably gotten. From the start, the sunroof stuck and would not open when parked in the sun. It went in several times. And now I just resign myself to pushing it up during the first hot spells of summer. One of the most frustrating problems was the car not starting. I push started the car the first time and dropped it off at the service department over the weekend. But it started when the mechanics showed for work on Monday. I talked to the service department. I stated that at times it would not start (no noise, nothing when the button was depressed). But since no warning indicators flashed, they were at a loss. Over the next year, the car was towed in 4 times for not starting. The first three times it was okay by the time they got to it. The final time, I picked up the car after a week of being in service. The very next day it failed to start. When I dropped the car off that day, I also left both sets of keys and told them I didnt want the car back. They actually found the faulty wire that time and it has started ever since (almost a year now). Now the problem is leaking. First, the water in the spare tire well, now under the passenger side mats and on the driver side, is causing a soggy seat belt. It has been in twice or more for leaking. I live in CT. It rains. Get over it. Occasionally, I go to the car wash, get over it. And, heres the kicker: I do park outside. This car needs to get over it!

On 07 July 2011, I went out to my car and the right quarter panel window of my 2006 MINI Cooper Convertible was damaged. I called my insurance company and they took the car for an estimate. I was told that it was going to be in a shop for three weeks. Unfortunately, I couldnt leave it because I could not pay for a rental. I had lost my job and couldnt afford a rental so I settled. I was then told that I could get my window fixed at home. It would not be a problem, I thought.I had three appointments for a window replacement and in all three times, no one showed. Nevertheless, I ended up calling Lauderdale MINI Service. I was informed that they had a window stock. I said, “Fine. I’ll call you back.” When I called back, they told me that they had the wrong part number so the window was not available. I asked if they could order me one. They said, “Sure. It will take a few days.” So, I continued to drive the car. After a week, my clutch went out and I had to get it towed to a shop. When the mechanic looked at it, they informed me that the hydraulic line base split into two. And when they called MINI, they were told that the part was on back order from Germany. I said, “Wow. You’re kidding.” So I called MINI service about the rental and I was told that it was up to the dealer. I had called and spoke to Jessica about the issue. I informed her that I felt like I shouldnt have to pay for a car rental because it’s not my fault that the part is on back order. She told me to call MINI customer relations and there was nothing she could do. After I told her that I had already spoken with customer relations, I was passed the buck at least five times.Now, Im told by the mechanic that my battery is dead when I had just bought it two months ago. I have had a rental for three weeks and my car is going to cost well over $1,000.00. Still, I have no window because it is also coming from Germany. It seems like I am back to square one and I have no windows, no car.When I called the service department, I spoke to a woman named Ann, who gave me all the information on my window. After a few days, she claimed that she never spoke to me so I’m still getting nowhere. I will never buy a MINI again. They are crooks.

I own a 2007 Mini Cooper S. Its had all regularly scheduled services done at dealers (Phyla, PA; West Chester, NY; and Darien, CT). Now the car has about 50,000 miles on it (December 2011). In June 2011, with about 38,000 miles, the engine started having rattling sounds during cold starts. I brought it to an authorized Mini dealer (West Chester) and they found nothing wrong. Two weeks later, the sounds got worse, and the dealer checked the Mini. They said the timing chain guide (plastic) had cracked in pieces and scattered though the engine and oil pan. The dealer replaced timing chain, timing chain tensioner (broke too!), and guide. Its been less than 6 months (December 2011), and the same sounds are coming back!There is obviously a timing chain mechanism design flaw (just Google Mini Cooper timing chain problems). Mini should correct this on all affected vehicles. Mini is responsible for their design mistake regarding a substandard timing chain box.

Since March, 2018 I have been attempting to resolve an issue with the timing chain in my 2008 Mini Cooper S. The timing chain failed while the vehicle was in motion on the highway, causing the vehicle to lose power. A dealership has confirmed that the timing chain is in fact the problem with the vehicle (it may also be the case that the timing being off is causing issues with the valves). Conversations with the Mini USA customer relations and even BMW North American (their parent company) lead nowhere, and the manufacturer refuses to take any responsibility for the defective timing chains in these vehicles. There was a class action lawsuit regarding these timing chains, but Mini somehow got away with not having to issue a recall despite the obvious safety issues caused by timing chain failure when a vehicle is in motion. It is criminal that Mini refuses to issue a recall and refuses to assist customers with necessary repairs associated with their defective manufacturing. These cars are fun to drive when theyre operating properly, which isnt the case most of the time. I would rate them lower if I could, but 1 star is the minimum. Buyers beware! Mini is a shifty and dishonest company that will not stand behind its product.

I have (had) been a loyal Cincinnati Mini customer for the past 10 years. I have owned 2 vehicles and feel that that should have warranted me as a loyal customer. However, after my latest vehicle had over $15,000 in repairs, causing it to be worthless to both me, Mini and anyone else, I am not a happy customer. ($3000 repairs in February. Repairs in May estimated initially to be another $3700 (transfer case issue due to All Wheel Drive poor design), ended up being the transmission failure (additional $7000 estimate plus $4500 clutch that was shot after they put the transmission back in). I was willing to accept my loss, but the dealership decided to rub my nose in the issue by charging me an additional $590 to tell me the news. (And they expected me to be grateful for not charging me restocking fees for the parts they could not use).I was told by the service department manager (Steve) that he would look into my loyalty dollars and see about getting me a deal on a new mini. (This was on Friday afternoon). By Monday, I had to call them to find out what the deal was. Basically it was a used demo that had no special features and would cost me over $30,000. I was basically treated like a piece of garbage. I ended up paying the $590 to tow it away (sold it for parts for $700). MINI offered to “keep it” in exchange for my $590 bill. How kind. There was no way I was going to give it to them to fix up and resell to an unsuspecting customer. I’m amazed that there hasn’t been a lawsuit come down about All Wheel Drive transfer case. Steve shared several times that it was a design flaw MINI was aware of. (I have been so upset by this experience it has taken me several months to calm down to report it. Do yourself a favor and really research the dealer and the car before buying).

I purchased a new 2017 Mini Cooper Clubman from Vista MINI in Florida. The car currently has 30k miles and it has had several problems. The car currently has a strong vibration problem which affects the acceleration. The car has been in a MINI Service Center 3-times for the same problem. The dealership acknowledged this problem to affect the non-turbo models. There is no current fix for this safety concern according to the dealerships service center. MINI solution to the problem is spending more money on a more expensive S model. If you are interested in purchasing a MINI please check all consumer complaints before the purchase.

My 2007 clutch had to be replaced on February 2012. I had to replace the valve cover, gasket, and hose at 37,500 miles. It cost $718.00. Then in March at 40,000 miles, I have to replace the timing chain at $2200.00 and a thermostat at $675.00. I have to pay out of my pocket for all the repairs since February 2012. I think that Mini does not built a car to last longer past 35,000 miles before you have serious problems. I am getting off the car and buying an American-made car. I have contacted Mini, and they said theyre sorry and that they will not do anything to pay for the repairs.

My daughter and step-daughter both bought new Mini Coopers in 2003. They drove them and loved them until 2013 when they both bought new ones - then my daughter gave me her 2003 because my Kia SUV was a repair nightmare. I have had nothing but good luck with the auto... And I do maintain it as Im supposed to. Last year my power steering pump went out - cost $808 to replace. Then I found out Mini had a recall on it so I sent them my bill and a letter. Now, remember, the car at this point was 13 years old, and they refunded every penny of my repair. Now how can you beat that? I get great mileage, everything works great. Yes, Ive had normal repairs done, but the only complaint I have is there is a lot of road noise which has been corrected with the newer Minis. PLUS... No one realizes this car is now 14 years old - looks like the new ones.

I bought a brand new 2006 Mini Cooper S convertible in April of 2006. I have brought the car several times to the dealer for maintenance and minor service while the car was under 36,000/3 years. I have complained three times before the 36,000 mile mark that the engine was loud from a knock/rattling I heard and each time, it was dismissed by the dealer as XYZ. Assuming they were the experts, I figured it was nothing. Well the knocking didnt get any better over time. The next time I brought the car to the dealer, it was two years later and the car had about 43000 miles on it. Keep in mind, I own two other cars, so driving this wasnt a priority. It was supposed to be my fun car. I hadnt returned to the dealer in two years because I thought the car was out of warranty and I can get oil changes cheaper locally. This time, when I went to the dealer, I brought this up again and told them specifically when the knocking occurs which they never asked when the knocking or loud engine sounds occurred. I gave them specifics and suddenly they were able to figure out what it was. Now that the car is out of warranty, its the dual fly-wheel that knocks and its $3,500 to repair. I was unhappy to hear about it because I brought it up when I bought the car but since I am not an auto mechanic, I didnt have the technical name of what it did. It also knocked the loudest when the car was cold. What pissed me off is that they acted like I was crazy. The worst part is they accidentally gave me a copy of a service bulletin from Mini corporate that addressed the dual fly-wheel problem from 2006 then revised in 2007 then again in 2009. The long and short of it, they knew about the problem and according to the service bulletin, it allowed for repairs at customer request. I called Mini corporate and told them my story. They said that they would help but didnt because the car hadnt been brought to the dealer in two years. In the end, nothing was done because the car was over four years old (although under the 50,000 miles limit). I did not know there was a drive train warranty of 4 years/50,000 miles. I assumed it was 3 years/36000 miles. This is the number one reason I didnt go back to the dealer. To add insult to injury, the dealer told me that if I had come before the car was four years old, they would have helped me, but I did, several times. Had I known how inferior Mini cars were, I would have opted for the extended warranty or another manufacturer. I have owned over ten cars and never had a problem like this. I do not have $3,500 sitting there waiting to fix a transmission on a new car, especially after paying over $30,000 for it. I asked the dealer to get me in touch with the regional person and Im still waiting three months later. I asked the dealer for something in writing stating that they are not covering it and still waiting on that. The sad thing is that, I have had better experiences with less expensive vehicles by other manufacturers like Toyota, Mazda, Nissan, Chevrolet, GMC, and Mercury.I just wanted them to honor the service bulletin they knew existed. I just wanted my car fixed for a known defect.

First of all, I drive about 25,000 miles a year. This is my only car... I didnt buy a warranty past 50k miles. I should have done both warranties, the service and the general warranty. You need both... I didnt do everything perfectly.... I have a 2006 Mini Cooper S with the JCW engine upgrade. Obviously, this car has a 6-speed manual. It is my 2nd Mini Cooper (my first was a 2002 that I bought used). Do I love this car? Yes. It has had issues, most of which are known to those who research the car before buying: 1) Thermostat housing. Its known to warp and leak. Ive had this replaced 2x. First time was under warranty. 2) Crank position sensor O ring. Replaced 2x. Failed at 75k miles and at 150k miles. 3) Front strut mounts. Once for each side (left/right). These failed because of road conditions - i.e. potholes that I was trying to avoid but could not. 4) Passenger side engine mount - This is a known issue where the oil leaks out. A solid mount wouldnt be a problem, but solid mounts create vibration and noise that many do not like. 5) Exhaust header flex joint failure after 150k miles. This will happen to many cars, not just Minis. 6) Clutch. There is a service bulletin on the throw-out bearing. Clutches are rarely covered under any warranty by any dealer because it is really easy for the operator to screw it up. In my experience, most people dont know how to drive a standard transmission. Im on my 4th clutch (the first was replaced under warranty, the 3rd was a performance clutch that wore out so I cant blame anyone...) 7) Brakes. These are a standard wear-and-tear.....8) Control panel for A/C and radio. Half of the lights went out and the whole unit was replaced under warranty.Ive upgraded certain parts with performance parts (suspension, struts, springs, brakes). Ive never had issues with the windows. I baby my car as much as possible. I feel for the people that bought the CVT. Its not a good transmission. I feel that any brand can have issues. I also feel that if you pay for a service warranty, truly understand the terms before you sign. If you dont understand the terms, get a 3rd party to help you. If you sign it and dont understand, you are still liable as it is a contract, so try not to get indignant with the service people. Ive had multiple cars, Ford, GM, Chrysler, Volvo, Saturn. Ive had weird problems with all of them.Will I buy another Mini...? Yes. Will I be very careful with what I actually buy? Yes... Do I have a bias? Probably. However, find someone that doesnt have a bias to a particular brand of auto... Very hard to do.

Recently my own Mini Cooper taught me more than I ever wanted to know about interference engines. Apparently when the timing chain tensioner fails it destroys the engine completely. So my Mini, which I love, which was my only way to get to work and help keep this country free is now sitting on a $12,000 repair bill. Now I am left to explain to my wife why she will not have a vehicle available to take my 2 and 3 year old to the dentists because I need to make money to pay off the car loan on a vehicle that is essential worthless. So needless to say I have done my research and have found a plethora of issues concerning the timing chain design problems that plague minis. From my perspective it just does not seem fair. I want to get this issue resolved. Better yet I would like to get this issues resolved without the necessity to take out a second mortgage.

I have a Mini Cooper 09 FOR 5 years with 51,000 miles. Just a couple weeks ago as I was driving home the engine light came on along with the temperature coolant light on. Right as this happened, I headed towards the next freeway exit when my car slowly started to slow down and came to a complete stop. My engine had died. I towed it to the dealership and told me that I needed to do a diagnostic test which I did and found out that my coolant had been leaking but later informed me that I need to do a engine tear down to see the core of the problem and figure out if this was the cause of a faulty part. Couple days later I found out that the dealer did not do the breakdown because Miniusa had told the dealer that a claim cannot be filed because through a remote, they said that since I drove 8 miles after the warning light, this is a case of negligence and nothing can be covered.Would anyone just stop there and then in the middle of the freeway when the warning signal comes on? Because the first thing on my mind was safety. Now I am stuck with a bill and a car without an engine which is going to cost me $8,000 to fix...when the car is worth only about $9,000 if it was running. Do not buy a Mini. It has too many problems which they know but would not acknowledge. Mini USA is even worse when it comes to customer service. All they say is that this is their policy and decision is finalized.

I have had this 2007 Mini diesel from new, and it broke down at 19,055 miles. I took car straight to Mini BMW garage, Bournemouth, where I was told that the clutch was gone. I replied that I have never had a clutch go on any of my other cars in all my years of driving, and didnt think that 19,055 miles was reasonable time to go on. They agreed and they quoted me a price of £1,300 if it was my fault, and they would give me a call back on if it was faulty or was my fault. They called later to let me know the clutch and flywheel were gone and was now going to cost me £2,500 and it was my driving that caused this. I replied to the above explaining that I never had a clutch go before ever, etc. They contacted the Mini head office who said that they would agree to not charge me for parts, but I would have to pay for labor, this being £1,334. This was including a further 10% discount from Mini BMW garage. I was not happy with this and sent 3 emails to Mini customer service saying I was not happy, but they said they thought they were being very fair with this price. My argument was that I have had car from new and 19,055 was not good, stating that this wasnt an isolated case as I had researched the internet on this matter, and they said internet information was not genuine and they take facts from their records (funny that as they are not available for me to see!).The outcome is that as the car had been with them for over a week and they had said if I take legal action, they would withdraw their offer. So as I needed the car, I agreed and paid for the labor. I am very angry on this and feel they just fobbed me off. I am now scared that something else goes that’s going to cost this much to something I think was not fair under the Sales of Goods 1979 Act. I had this car from new and have never let anyone else drive my car. I have been driving for over 30 years and have been complimented on my smooth driving. I am 48 and not a boy racer! But now I feel they have also insulted my driving. From their action, I will never buy a new Mini BMW ever again. I also cant afford to take legal action upon Mini BMW. So basically I am left feeling broke and angry on this matter.

We had several malfunctions on our Mini Cooper convertible, which the dealer was happy to cover under the original 48 month warranty. I actually got the feeling that the dealer was on my side. I then purchased the Mini Cooper USA extended warranty when the car had about 18 months left on its original warranty. About two years later, something in the steering failed, and also the trunk stopped opening. It took them a long time to determine that the latter was simply a short in the wires to the electric trunk opener latch in the truck door. The dealer appealed to Mini Cooper USA, but the response was that neither repair was covered because all rubber wear was not included in the extended warranty. It cost me close to $800. I felt cheated.

I would like to join a class action lawsuit if someone could please advise. I bought my 2007 Mini Cooper S Turbo in 2008 with just 14,000 miles on the odometer. I was told that the original owner was not satisfied with the noise that the engine made and that he returned the car to the manufacturer. At first I thought that I found a gem of a car at a local used car dealership because this Mini had every option available with very low miles on it. Little did I know just how much of a mistake I had made in buying this piece of junk.In six years I went through 2 timing chains and sprocket repairs after hearing the death rattle. Not once did a warning light tell me when I was low on oil. I actually had to top off the oil every 1,000 - 1,500 miles. This car consistently sputtered, hesitated, blew black smoke out the tailpipe and broke down so often I finally took the car to a local mechanic after my extended maintenance and parts warranties with Mini expired - which incidentally I paid an extra $5,000 for. After replacing the timing chain twice and being told by two local mechanics that my engine was ruined - Mini customer service representatives insisted that the engine was fine. I finally let my local mechanic work on the car and he found that the valves were gunked-up with carbon and one of them had a large chunk missing from it. After that repair - lo and behold my car finally stopped burning oil and I never had to top it off again between oil changes!In six years I had replaced: 2 timing chains, starter, thermostat, head gasket, water pump, rust in the gear box, rusty bolts in the hatch that were showing through the paint, knock sensor, faulty computer messages, leaking air conditioner, antenna shorting out the rear defrost and radio, service light not coming on, split o-rings, valve cover, engine vacuum, oil line, fuel inlet, leaking coolant, sensors, etc... Not to mention the multiple pieces of trim that blew off the car while driving down the highway and the multiple towing fees at $750 each.I did get some goodwill or NCs on my invoices after fighting for them and had to remind customer service every-single-time that I did indeed have a 2nd party warranty agreement that I purchased from the Mini dealership. I actually had to produce my contract each time that I was there for repairs because they couldnt find it in my records. After paying $5,000 in extra warranties, huge towing fees, $100 deductibles with every repair, lost time at work, thousands of dollars in repairs after the warranties expired, and the unnecessary grief and exhaustion of owning this piece of junk, I would never recommend that anyone buy a Mini Cooper. The customer service representatives were friendly.

I purchased a 2012 Mini with 9,000 miles from Mini Cooper of SF. The purchase experience was good. The service experience is terrible. The engine light comes on and to maintain the warranty, it has to go to Mini. There is a horrible monopoly in one spot. They, every day, give no details; make you wait; dont answer the phone; and put you on hold. I am used to Nissan that had one day turnaround and eleven years of routine maintenance only. A lovely experience. I am so incredibly disappointed and frustrated.

On February 3, 2014 I took my car in to have the key checked out because it was not releasing when the car was cut off. This has been happening for over a year and reported to my service guy at the dealership on my last visit for appointed oil change, etc. I was told nothing was wrong. On this appointment, with 16,000 miles on a 2011 Mini Cooper, and one month before the warranty expire because of the length of the warranty, three years or 39 thousand miles, I was told that the cup holder had leaked coffee or something brown into the computer and that had caused the problem. I was told that the warranty would not be covered for that problem and it will cost me $1200 or $1300 to repair. I just read another complaint and the customer was told that you should only used cans in the cup holder!!! Why are the customers not told this and why do they put the holders on top of the computer if this problem occur??? My car cost over $30,000 and something so harmful should be taken care of by MINI COOPER, NOT THE CUSTOMER!!!!!

First, I am not a fan of BMW products. We owned a 2006 X3 which was purchased CPO from a BMW dealer here in NH in 2008. Had the car 6 years and it was at the dealer 11 times during the first 3 years of ownership for warranty repairs. Torn engine mount, failed sunroof controller, failed ECM, failed radio, failed drivers seat memory module, failed rear door latch, failed brake light, failed airbag wiring harness, broken rear coil spring, phantom check gas cap lights, multiple instances of gross engine misfiring when started which the dealer was never able to diagnose. And then after it went out of warranty, the troubles continued: broken other rear coil spring, failed CV joint, leaking oil filter mount. In 2014, I convinced my wife to get rid of it at 105K miles because it was evident it was going to be a money pit. She then saw and fell in love with a used 2012 Mini Clubman S. Low miles, well taken care of, fun to drive. Seemed to be a good car and I stupidly thought that, perhaps, BMW had addressed their quality problems so we decided to buy it. The Mini had 23,000 miles and was still under warranty so I thought, OK. The car is a daily driver that is not abused in any way and only driven on paved roads.Car went in for a service at ~28,000 miles; nothing wrong. Went in again just after the warranty expired for a bad ABS sensor in the right front wheel and the dealer was nice enough to fix it at no charge. Run flat tires were replaced with non-run flats at around 40,000 miles. Always hated the run flats because of the very harsh ride. You could feel every imperfection in the road. New tires were great and gave a much improved ride quality.Right around 50K started hearing a droning sound from the front end and the tires started wearing oddly. I am an excellent mechanic and have been doing all my own car repairs for 40+ years. Oil changes, brakes, shocks, engine repairs, transmissions, torque converters; you name it, Ive done it. So I quickly found that both front wheel bearing assemblies were bad. I mean wobbly, sloppy loose bad. Car was out of warranty and I knew Mini would charge an arm and a leg for the repairs so I did them myself and saved $$. Not happy about wheel bearings going bad at 50K but, oh well, it wasnt an expensive fix because I did the work myself. Probably caused by the crappy run flats transferring shock and vibration to the suspension.No further problems... until now. Car has 60K on it. The other day all three of our cars were in the driveway and my sons and I were standing there when we heard a loud ping sound. Couldnt localize where it came from but I know the sound of metal snapping. So we quickly checked over all three cars but didnt find anything. A few minutes later I asked my son to move the Mini so we could play basketball. He starts the car, puts it in reverse and the moment he started moving backwards, the left front dropped 4 inches with a bang. Got the car up on the jack, pulled the tire off and saw that the coil spring had snapped about 1 full coil up from the bottom. I was dumbfounded!! I couldnt believe that a car with 60K would have a spring break let alone break while sitting still in the driveway. Other than the BMW, Ive never had a car or know anyone whos seen a coil spring break like that. Thank God it happened in the driveway and not on the highway as Im sure that the sudden change in the steering geometry would have caused a potentially fatal accident. Called the Mini dealer 35 miles away in Bedford, NH and explained the situation and that I wasnt happy about the coil spring breaking at 60,000 miles and potentially putting my wifes life in danger. I asked them to send a wrecker and get the car and replace the spring for free because a close inspection of the break clearly shows it had cracked at some point, rust had invaded the crack and weakened it. This is clearly a defective spring. And, while they were at it, they should also replace the right spring too because now it couldnt be trusted either. They refused to do anything. Said it was normal for springs to break. Told me it was my problem to get the car to them if I wanted them to repair it but they would be happy to sell me a new strut assembly (which they didnt have in stock anyways) if I wanted to do it myself. We went round and round about the defective spring being Minis problem, not mine, but they wouldnt budge. Suggested I contact Mini USA which I did. After waiting 3 days I was told that I had to get the entire car to Mini of Bedford, at my expense, for them to diagnose the problem but that there was no guarantee Mini USA would pay for the repairs. I told the nice woman that the diagnosis was very simple: The defective spring broke! I explained that it made no sense for me to pay $250+ to have the car towed to the dealer, have them diagnose the broken spring at $120/hr, then tell me I would have to pay for repairs (another $300+ for the part(s)/labor) when I can get new strut assy for $125? So I would potentially be out $500+ for their defective spring. And, if I chose to repair it myself, then Im on the hook for another $250 tow back to my house? She said Mini USA would not consider doing anything until the car was brought to the dealer. I offered to take pictures of everything and send them to the dealer and anyone else inside Mini/BMW. I offered to remove the strut assembly and bring it to the dealer for them to look at. I offered to do all the repair work myself if they would pay for the parts, since, after all, the spring is defective. She refused it all. I asked if we could escalate this issue higher inside Mini USA. She said no, she was the highest person who would deal with this.Mini/BMW does not stand behind their products at all and does not give a crap if their defective parts could cause fatal accidents. I am through with BMW forever. Ive learned the hard way that they build cheap cars with cheap parts and that they could care less about driver safety. A coil spring is a vital part in any suspension and for one to break with so little miles is totally unacceptable to me. Theres no way you can convince me that its normal for a coil spring to break under normal use.When the X3 had the broken rear spring I did a little research and found that BMW used to use a German company for their springs but had switched to a Romanian company in the early 2000s. Since then, hundreds of reports cases of broken suspension springs across all their models. I dont know why there hasnt been a NTSB investigation/recall yet.

I have a 2014 Mini Cooper coupe and I love it - not had one bit of trouble with it, love how it handles on the freeway. Only one problem - me 5ft2 perfect driving position - can see all the through the windows, hubby 6ft has trouble that cant be a bad thing stops him from driving my baby. This is my 3rd mini, before this one I had a 1974 Mini Cooper and a 2007 Mini Cooper - just love these little cars.

I purchased a 2009 mini cooper hard top used with 50k miles from the dealer. I was so excited to finally have my dream car, and for a year or so it was heaven. The car was not only adorable, but fun to drive and got great mileage! Sure, I had to pay for premium gas and oil changes were around $100, but the car was a dream. That was until the problems started to roll in at around 60k miles. The car began making a thumping noises after driving (with the engine off) and the engine would idle very loudly and even rattle. I took the car into the dealer and they assured me it was fine. One night the engine died. The cars oil had leaked into the engine and the engine was done. Third parties wanted 7k for a used engine replacement and mini wanted 10k for a new one. I was devastated. That was over half the price I bought the car for. I found someone who was willing to rebuild the engine for 4k. That lead to more nightmares. Several nights making long drives the car just died on me. Stranded and alone I had to have a friend pick me up and the car towed (at least 3 separate times) and then wait for weeks while the car was in the shop. The car was on its last leg, huffing and puffing around, ready to die any second. More repairs were needed. Mini said the car needed a part, I cant remember what it was, and that it would be $900. And only mini had the part. Recently I was rear ended on the freeway and the car was totaled. It was a rare case where the person whose car is totaled is actually happy about the situation. I still have a few more payments left on the car, and the payout will cover just a bit more than the payments and the engine rebuild, but at least this is done. Everyday driving my mini was uncertain. I never felt safe in the car. That said, I loved the car. It was still fun to drive and so cute, but the anxiety and maintenance repairs make this car criminal. I would not recommend this car to anyone unless they are leasing it or rich and dont care about all of the repairs.

I bought my 2007 Mini Cooper S in July 2009 and in August 2009, I had to have the car flat bed towed to San Antonio because the clutch and all parts had to be replaced $2793.09. March 2011 - water pump drive belt cracked $1106.52. October 2011 - excessive carbon buildup $851.00. March 2012 - timing chain $941.98. Total spent on repairs $5693.05 in 2 years and that is with them discounting.

I purchased a used 2002 Mini Cooper S from Mini of Knoxville with 70,000 miles. I thought I was purchasing a great car from a reputable dealer but it turns out that I was not. After just a day, the clock stopped working and a screw fell out of the lower dash trim a week later, and in the following month my windshield trim began pulling away.Within the first month, my power steering pump went out nearly killing me and my wife. I tried to work through Mini USA and I was told to take it to a dealer who preceded to tell me that I had a whopping $3400 in repairs! I told them I just bought the car a month ago from them!The car needed a P.S. pump ($1400), front control arm bushings, total shot ($900), crank pulley, balancer and belt which were warped ($500) and that the brake fluid and coolant were in terrible shape (remaining cost). Oh, and by the way, the tires were the wrong size. This is the way I was sold the car. After fighting with the dealer, they replaced the pulley and belt and thats it. They told me sorry, you bought a used car. Where is honesty? I thought we had a lemon law, it turns out not so much. I removed the p.s. pump and had it sent off and rebuilt for $225 and replaced it 30 minutes total. WHY is MINI so EVIL?

By now, every Mini owner should know of failures of the power steering fan, pump and guard and that Mini has pledged to repair or reimburse owners for breakdowns. I applied for reimbursement in May 2013 and have yet to receive it. Mini-USA told me it may be 2014 before I receive my check. My automobile shifter linkage failed within a month of purchase; it spent ten days in service five or more times the first year alone for this one problem that freezes the transmission in 5th gear. Repairs made to this automobile: At 90k miles, I have replaced 4 or 5 clutches, a transmission, power steering pump, throttle body, ac compressor and condenser, fan, alternator, both power window regulators, motor mounts and rear strut. Electrical harnesses connected to the warning system are prone to fail from rainwater leaks and/or require cleaning service. Dealer estimated charges for each of the above repairs average 1000.00 USD. Responsiveness of dealer and manufacturer is almost non-existent. I estimate I have paid 6000.00 for repairs in the last 30,000 miles.

I have had a problem with my 2005 Mini Cooper S, off and on, for about a year. The passenger side air bag light comes on in the dash and over the rear-view mirror. This was occasionally on, but when someone sat in the seat, it would register the seat as occupied. Then occasionally, it would come on, when no one was in the seat. Now, it is coming on and staying on, even with someone in the seat or not. I called my local Mini Dealer and spoke with a man in the service department. He knew exactly what I was talking about, but stated that there is no recall with this problem. It seems to me, that if enough people have this concern, Mini would have no choice but to issue a recall on this defective sensor. Especially, someone was seriously injured before.

My wifes car is a 2007 Mini Cooper S with about 98,000 miles. We bought it used at approximately 14,000 miles. It is on its third engine! There has been so much maintenance on the car. I can only begin to list the problems. The entire panoramic roof cassette had to be replaced. Currently, it is burning about 2 to 3 quarts of oil every 600 miles. The exhaust is making a noise which approaches the threshold of pain. The radio behaves erratically such that you only get one am station. When the battery inside the key fob died, we had to replace the entire key fob! The car devours tires and brakes. While I have mechanical breakdown insurance, we still had to pay costly deductible payments. Mine is for sale - cheap!

In 2013, I bought a used 2012 MINI Cooper S R56 with 10,000 km on it. I like this car, but in Jakarta theres many broken road...and this car is low...so Im not recommend this car in broken road city. The performance is amazing...Im happy about it. But in Jakarta, the used car cost 60k USD...so its expensive here.

We purchased our new 2010 Mini Cooper Sport with the hopes that it would be a reliable, sturdy commuter car. The problems began two years later, in May 2012, when the check engine light illuminated. The car was taken to our local Mini Service Center, where the timing chain tensioner, seal ring, and auxiliary water pump were replaced due to recall. The check engine light illuminated again in December 2013, at which time the car was taken to our local service garage, who replaced the spark plugs, ignition coils and leaking valve cover gasket.In March 2014, the check engine light again illuminated, resulting in another trip to our local Mini Service Center. The repairs required on our four year-old car included the following: turbo heat shield replaced (recall); carbon cleaning due to carbon buildup on the intake valves (parts $251.92; labor $1350.00), fuel injection and induction system cleaning (parts $54.00; labor $100.46), leaking oil filter housing and turbo oil feed line replaced (parts $436.29; labor $1822.50), leaking vacuum pump replaced (parts $525.61, labor $202.50), leaking water pump replaced (parts $201.79, labor $652.50), oxygen sensor replaced (parts $317.73, labor $157.50). Unfortunately, just 11 days later, the overheating engine light illuminated and coolant was running from underneath the car. The car was again taken to the Mini Service Center, where the following repairs were made: T-Stat replaced (no charge due to warranty), Turbo boot replaced (parts $140.00, labor waived).I contacted the Mini Corporate Customer Service in April 2014 to file a complaint, requesting reimbursement for at least some of the charges, as our car was only four years old, has been well maintained, had just missed the maximum mileage of 50,000 for warranty coverage by 4,000 miles, and required what I would consider an excessive amount of repair. My experience with Mini Corporate Customer Service was very disappointing. The agent ultimately assigned to my claim not once spoke with me in person. My claim was denied, but I have concerns that my claim was not properly documented. Additionally, attempts to speak with a Supervisor about the service I received, and concerns with my claim, were blocked; I was informed there is no management that can be contacted.

Wife had been looking for a new car - one that fit her personality - and chose to order a top of the line Mini - specifically a fully loaded 2018 John Copper Works Countryman All4. After waiting for almost 3 months to have the car delivered from Belgium (BMW) factory, we took the train down to Mini of Portland to pick up her car. Upon inspection we noticed white slime coming from outside the interior of the car and staining the black trim. Dont worry we will get it cleaned up for you was the managers response. After driving it 2 hrs home we noticed the next day that the black trim molding was stained as the Clear Coat (extra by necessary living in the west mountain regions) was bubbling in the front bumper. After taking a day off from work it was brought to the dealership where I was told there was a notice out from BMW but since the model of the car they hadnt received it from corporate so they wouldnt fix it because they would have to pay for it!!! Doesnt matter that it is a 4 hour round trip plus my cost away from work. When it was finally down they had to take the hood off and clean the slime off - which is what they stated was used to prevent rust from the transatlantic trip. OK, if that is what a takes, even if it was inconvenient and expensive for us. She wanted her dream car and said it was worth it.A week later the white slime was back and a passenger side window molding fell off. Called the dealer and they said to take another day off from work and make a four hour trip down - of course at my convenience. While trying to figure when to take it down we noticed that some of the Mini medallions that are throughout the interior were starting to peel off. I finally got so angry I called the Mothership; BMW of North America to file a complaint. After nearly 2 weeks I was called today and told I had to deal with the dealership only and that BMW of North America had nothing to do with.I said the dealership didnt build it and that BMW of North America does indeed have everything to do with it as they represent the brand and factory and that whether a car cost $5,000 or $5,000,000 there should be no reason for shabby workmanship. He continued to deflect responsibility until I just disconnected the call. So, save your money and buy a used Yugo - at least you know the quality to expect.

I bought my 2005 base Mini convertible with around 35K miles on it. I bought at a BMW/Mini Dealership where it was first purchased. I was told I would be the second owner and that all services were performed there since new, including the first power steering failure. OK now, the certified vehicle they sold me had a throw-out bearing noise the day I bought it. I heard it at night with top up and windows up. Same thing with the power steering; it was failing when I bought it. I am sorry, but how can a BMW/Mini tech certify such vehicle? They had had to know it had these issues. Not to mention, the seat memory function was also broken from the day of purchase. All the issues were done under factory warranty. I also bought mercury platinum extended warranty. Now moving on, around 50K, the throw-out bearing noise is back big time. Power steering is noisy again. Once again, theres warranty on the throw-out bearing. No luck with power steering; I had to keep bringing it back and was declined every time until it actually started going out while driving! No power steering! It was replaced at that time under warranty, and the new pump was so silent at first. I was thinking hmm Im still upset they sold me a certified car with major money issues but this time the power steering is fixed good.The vehicle now has approximately 75K. All services are up to date, including resealing the oil pan and the third valve cover reseal. But what the salesperson never told me was that the interval for resealing the oil pan is every 40K as normal maintenance! And the clutch is shuddering; throw-out bearing is about to fail, getting really, really loud knocks with clutch out squeals if I push it all the way down. I have to push it down and let up around 1/2 to 3/4 of an inch to stop the squealing, but its still making noises always. So the clutch components are no longer under warranty. Great. And the power steering that was so quiet a short time ago has a crazy loud noise again and the fan is staying on after the vehicle is shut off. I can make it stop by turning the key on and off a few times. I should be covered for this power steering unit with a deductible through Mercury, but they seem to ask for mega diagnostic tear down money. Its like pulling teeth to get them to even act human. I will do that for the power steering, because its bad and I know it will be covered. (crosses fingers)I was told that the noise of the clutch components may be internal in transmission, so I should authorize a lot of money, so they can tear down the transmission and see. Really?! its the throw-out bearing again. Im not authorizing that obvious leap of faith/ripoff. Did I mention I have records from the first month I owned the car about it not going into reverse unless I for up to 3 full minutes mess with the shift left through all gears and let clutch out in each gear and a little trick I learned while being honked at because I wasnt backing up fast enough? The trick is hold the lever towards reverse and ever so lightly release the clutch pedal a tiny bit. It will go into reverse that way, and it may do so with super sweet sounding ultimate grind, which it does all the time even when not forced to use an awful trick to get it moving backwards.The last time I brought it in, the service writer, whos always so full of tech wisdom, actually duplicated the problem. The service writer could not get the vehicle into reverse, and after fiddling a while, it went in with an ultimate grinding experience. But now, this tech savvy writer has forgotten everything, and it seems all that schooling (self-proclaimed) and BMW-awarded service training has slipped the highly trained uber techy service writer into saying that he wrote on the repair order duplicated in service drive. But I still have to pay $1000 plus for tear down to prove to Mercury what I have been telling them has been happening since it was under factory warranty! I could duplicate it everyday, every time they said cannot duplicate.Well, they could have if they drove around more till they did duplicate it for not long rather than sitting in their service bay shifting the lever around! Both window regulators are starting to fail. I loved this car. Its fun. it looks great, but I would not recommend one to my worst enemy. Oh, thats BMW/Mini. Hmmm. Well, you know what I mean. I will never recommend BMW or Mini without saying They drive great, but youre gonna pay.I tell people if they must have a BMW or Mini and dont mind being in the shop a lot, lease it. Never buy anything from BMW! They are literally spot on to provide you with the ultimate repair bills as soon as warranty is out. BMW is criminal in this kind of treatment of their customers! I mean, really, its pretty well-established. The clutch components suffer from poor/weak/cheap design and parts. Its 2012, and BMW still doesnt even offer a superseded part number for clutch components; no upgrades for you! This is the absolute end of my time with BMW. They can keep their cars, until they fix whats wrong and stop covering up long-standing design flaws. Oh my God, some give them Japans phone number or even GM for that matter for a little updating on their still being filled with really bad electronics from silly connectors long obsolete to flat out... Really, you havent stopped those light from flashing yet! Which ones you say? I say pick anything. BMW electronics and Mini are in need of some updating.Lets say bye BMW/Mini. Never again. I cant wait to get rid of this nightmare that could have been so nice a car if they finished it. Too late trading it in on anything nice, even nicer not made by your dishonest bloated overrated company that smiles at you while lying and... I cant wait for my Lexus or Acura or Infinity. I just cant wait. Own up to the problems. And at least, if youre going to charge for a repair that is due to your cheap poorly placed parts in a nice car, offer a fix. Its called a fix! You know, like when you dont sell a Mini owner the same ** part. Why just fix it!

I bought my 2014 Mini Cooper from the Escondido CA store and I have had nothing but problems with the car. When I have brought my concerns to the service advisor they were rude and unhelpful. I do not recommend purchasing a Mini from this dealership.

I purchased a 2003 MINI (used) in 2004. Loved the car, but the engine was constantly overheating. While it was still under warranty, I brought it to the MINI dealer in Annapolis, MD. The service department would do various things to fix the overheating, such as, replace the radiator cap, replace the thermostat, replace fan motors, replace hoses and refill the fluid levels. Nothing they did under warranty was a permanent fix. After the warranty expired, and the problem continue to rear its ugly head, I was informed the head was warped. Several thousands of dollars out of my pocket later, that problem was fixed and finally the car no longer had overheating problems. Then I started hearing noises which I suspected were coming from the transmission. I changed the transmission fluid hoping that it would fix the problem and noise; however, the noise - albeit aggravating - continued, yet the MINI continued to operate at a normal rate. Then the unexpected happened: while driving at just over 30 mph, I heard a sound of metal breaking and the car was powerless. Under 90,000 miles and the transmission was gone!

2012 Mini Cooper Convertible. I love the car but a problem developed over a year ago. The problem is the fuel gauge. It is entirely inaccurate. When it reads half full for example, there are just 3 gallons left. The dealer has tried several times to fix the problem without success. Anyone out there that has had this same problem, please post your experience.

In the end, I was contacted by an Executive Customer Care rep about my BBB complaint. She was professional and courteous and did everything she said she would do when she said she would do it. This was especially impressive given that her responses relied on many people around Thanksgiving vacation time. She said she did not know why the Regional Management Team would have turned down my request for a tow, and a week later, their decision was overturned. A day later, the new dealership contacted me to arrange EVERYTHING for just two days later. They said my MINI would be finished by Friday, but on Thursday morning, they contacted me to say I was moved to the front of the line and would have my MINI towed back to me, fixed up as good as new, a day early. MINI USA paid for EVERYTHING, and the new dealership took care of arranging the tow and the repair. When you find the right people in the company, I think they really DO care about their customers! One star off for having to work so hard to find the right people, but they have re-earned my business!

I just had to take my mini in for service as it sounded like a diesel it a metal rattle noise was quite obvious. I have a 2010 mini Cooper S that fell victim to a large issue two years ago just prior to the mini Cooper recall. I am not sure if that recall is in fact tied to anything with this problem but that day the car had to be towed to the mini dealer and it only had 30 some thousand miles on it. Now Ive taken it in and been told the timing belt tensioner is in fact completely broken and the car drained 2 1/2 quarts of oil- etc etc. The car only has 52,000 miles on it and if it even looks different I take it to the mini dealer for service constantly. This is not a car that has been even given the opportunity to be neglected. This particular repair is over $2400 which is extremely odd especially with this particular car and how Few miles its driven. I have now read about the unusual timing belt problems with Mini and I would strongly suggest as per a previous article I read that the 2010 Mini be included in this consumer complaint - and seriously looked at as a potential recall problem. This can be extremely dangerous and needs to be addressed immediately. As I write my car is in for service of this exact issue crossing my fingers.

2 years ago I found my beautiful Mini Cooper Convertible, a beefy convertible Ive wanted since I was a kid! Fun to drive, but not nearly enough power. I feel like it was at the Dealer getting services a LOT but it has 19800 when I bought it and MINI covered the maintenance/service up to 36k which was a dream. Tires had to be replaced due to them not being rotated before I bought it. I did start driving 25mi each way to work in LA traffic, but this has gotten ridiculous.In May of 2016, I noticed my oil light coming on. I didnt think much of it until my bf took it to the dealer and they stated it was just really low on oil and since I was close to getting an oil change, went ahead with the service. 5 months later, I noticed my car sounding weird/grinding. Checked the oil level and you can barely read the stupid dipstick in this car. Looked fine. Checked an hour later and it was EMPTY! There was NO OIL. I filled it with 5 quarts! I called MINI and other shops and this is normal?! How is burning 5 quarts of oil and having little to no notification normal?FFW to Feb 2017, My car has always lacked a lot of Gusto, but I noticed it sputtering then accelerating, esp on the freeway around 2000 rpm. I thought it may be a fuel line issue and needed a flush. Called a mechanic who specializes in MINIs, and he said it sounded like it may be a trans issue. Took it to AAMCO and sure enough my transmission has to be rebuilt/replaced. MINIs powertrain warranty ends at 4 years 50k, My car is 4 years, 3mo and has 51k. BS! Luckily I purchased an extended warranty from the dealer I bought it from (not MINI) and after fighting with them for a MONTH I got a used transmission put in. Im getting it today but Im seriously considering getting rid of it even though I am upside-down on my loan. This is ridic! Not to mention the stupid brakes/rotors have to be done at the same time. I knew MINIs needed some love, but this is too damn much.

I love the car and I have always wanted one. Its small and compact but plenty of room. Its excellent on gas too. You can go two weeks on a tank of gas. But I dont like that its a 2 door. When trying to put something in the back seat its hard to do. Ive had the car 2 years and the thermostat sensor has went out on me 2 times. I recently had to replace the thermostat and you have to replace the whole housing unit. Overall the car is fancy looking and if I was to buy another car it would probably be the same model with a little more options to it.

We purchased a brand new Mini Cooper, a countryman. It has less than 7,000 miles on it and there was a nail in the tire. The repair shop replaced the one tire with a different brand without our authorization. We explained on a brand new car we would like the tires to match. We purchased this car for over $30,000 new less than 6 months ago and are concerned that there is no replacement tires on a brand new car?

I am shocked and dismayed about the number of complaints about Mini Coopers! I too fell in love with my 2009 mini (cute as a box full of kittens!) LOVE driving it! BUT at 25k the water pump went. At 49k the top had to be replaced. Later the thermostat housing cracked, and at 82k a freeze out plug inside the timing chain housing blew out, blowing the engine. I still love the car and am going to fix it (at about $8000 for a used engine). I think BMW should be responsible for all of these engines blowing! What if the used engine blows? I cant afford another 8 grand!!!

Last Friday when I was driving home and my 2015 Mini hit a telephone pole. The car hit the pole at about 35 MPH on the drivers side at about the level of the headlight. The car was totaled. For whatever reason, no airbag was deployed. I hit the steering wheel with my chest and have bruised ribs but fortunately I am going to be OK (I was wearing a seatbelt). Up until now I was a loyal Mini owner (this was my second) but I am concerned how this car could hit and damage a telephone pole so severely it had to be replaced, without airbag deployment. More of a concern was what if the accident was even more severe. Has this happened to others? Obviously, my replacement vehicle will not be a Mini but others may want to use this as a cautionary tale.

I am very disappointed at the sales practice in Morristown Mini. I would advise DO NOT buy car there, I had to bear a loss of $17,000 because this dealer didnt disclose the tire information at purchase. As a loyal customer, we have purchased a Mini Cooper two years ago and were satisfied with the car. However, when we decided to replace another car and got a Clubman last Sept. in the same dealership, nightmare started not long after the joy of having a fully loaded clubman. First snow, which as a resident of NY and NJ for 20 years, was really nothing, my husband though couldnt even drive the car up to a small hill for my daughters music lesson, it was a dangerous zigzag. We couldnt figure out why. Until we sent car to dealer, they told us its performance tire and cannot be driven under 40 degrees. Since we bought it at 6k miles, no one bothered to disclose this information to us. And I tried to call dealership, the manager never called me back. We are caught off guard. We purchased a car not suitable for weather here. After that, the car is mostly stalled on the driveway, upon recent snow storm, when we had to go out during and after snow to get gas for generator. So, after 5 months of suffering, we terminated car with $17K loss... Bought a SUV with all season tire.

I bought the 2007 Mini Hardtop at 61K. Within one week the timing chain needed to be replaced along with the valve cover and leaking oil, it ran poorly and stalled out at lights. The cost to me was $3K. I cant afford a car like this. Who can? I want to sell it and Ive only had it 4 weeks.

I bought 2 Mini Coopers. I bought a red 2005 Mini Cooper automatic for the wife and a silver 2008 Mini Cooper S 5 Speed for myself. I dont know which one of the 2 was the worst, they both spent more time at the repair shop than on the road. For such a good looking car they turn out to be one of the worst cars on the road. Even my dads old Ford Pinto was a far better car than the Mini Cooper. Why do people keep buying them is beyond my expectations, we spent almost what we paid for them in repairs, when it wasnt one thing it was another overheating problems, brake problems, electrical problems, sunroof problems, but the worst was when we needed to get the oil change, we was charged $110. per car. We will never ever own another Mini Cooper again even if they were giving them away for free, my wife Mini Cooper only had 46k miles and it was always in the repair shop. Meanwhile we traded her 2001 Honda Civic with a little over 200k miles and in all the time she had it, all it ever needed was oil changes and a new timing belt. We were so scared to drive too far from our home because we didnt know if we make it back home that night. BMW Mini Cooper thats one in the books for you as one of your biggest failure.

1009 Mini Cooper S suddenly died after getting off of OC Freeway in the rain. Dead stop, cannot even charge battery. Clunking noise the day before. Towed to auto repair ... tensioner broke, blowing up gaskets, engine. Repair $3500. No warning light came on at all, just the clunking noise the day before. Engine light comes on for low tire but not tensioner!! The thermostat went out last month and then a week later the water pump. $5000 in one month. Very discouraging since after reading about it the tension will break again, since its such a bad design. Is there anything one can do?

I have a 2005 Mini Cooper and from the day I purchased it used, Ive had issues. I took this Mini in regularly for any service it required, however, Ive had to replace numerous things under warranty and now, items out of warranty. I only have 60k miles on it and I was told that I need to replace the transmission because it makes noise but in order to take it apart and look, you cant rebuild a mini transmission so a new one would need to be purchased. This is after $5,000 in other repairs out of pocket after the numerous repairs under warranty. Now I have to fix the alternator as well, which just went out several days ago. Other parts that have needed replacing include an engine temperature sensor (3 times), the bottom plate underneath the car, the battery (twice), power steering, brake pads and bearings. Im so sick of fixing things on this car! Never have had a car with so many issues.

I bought my car as an ex demo. I absolutely love the car, but the service isnt great and the build quality is not what I expected. The hood broke after a year - instead of making the components of the hood out of metal, they are made out of plastic. And guess what, one tiny part snapped. And as a result, the entire hood cover had to be replaced. On a positive note, it was covered under the warranty. Had it not been, I was told the cost would have been 1,800. No one in the UK had a hood in stock, so one had to be ordered from Germany. Of course, whilst waiting for the hood to arrive, it rained pretty much nonstop (when doesnt it in the UK?). As a result, the boot was filled with around 2 inches of water. By the time the hood arrived, all the carpeting in the boot had fungus growing on it and also needed to be replaced. The garage also allegedly spent 24 hours drying the boot out. The car is a UK registered 09 plate with less than 30k on the clock.I have taken my car into the Mini BMW garage today as (1) it is due a service, (2) the boot keeps opening as I am driving along, and (3) it needs new brake pads. Firstly, the service - the guy reads out a list of things that are due to be done under this service including new spark plugs. I pointed out that the garage replaced the spark plugs at the end of October and charged me 200 to diagnose the problem and replace the sparks. Why didnt they mention then that they are covered under the service? Then, he said they didnt replace the sparks - it was something to do with auto sensors. I pointed out I have the receipt and it clearly states spark plugs were replaced. I then get a story that it is something to do with the Mini service pack. Had they gone wrong this week, the cost would have been included under the service. But because it went wrong 2 months early, I have to pay. I pointed out that surely if they go wrong early, they are faulty. But no, that was not the case. It is just my bad luck they failed before the service was due.The reason why the boot keeps opening is because all the components in the boot have rusted and corroded. I immediately linked this problem with the faulty hood and all the water that got into the car whilst I waited for a replacement hood. Apparently, had the components corroded immediately, they would have been covered under the warranty. But because the corrosion has only now become apparent, it cant be covered under the original claim and basically I have to pay for any repairs as it is just normal corrosion. Now, firstly, corrosion does not show up immediately. So I couldnt have bought it back straight after the hood was replaced, as I didnt know there was a problem until now. I think anyone with an ounce of common sense would realize a car boot that sat in inches of water is likely to suffer early corrosion if not dried out correctly. But, hey, not according to Mini BMW. On that basis, I must conclude that all their cars after 3 years are likely to suffer serious corrosion of the electrical components in the boot or just general corrosion all round. Brake pads are being replaced as we speak - BMW charge around 200 for them. So before having yours done, check the price of other reputable garages. It is also worth comparing prices with other Mini dealerships. I only have a short drive to another county and the tires in my garage are 165 fitted each. But if I drive 20 miles down the road to another BMW dealer, they are 118 fitted. It has been a fun quirky car and I do love it; however, I will be reverting back to a Mazda MX5 - never had any problems with Japanese reliability.

I had a Cooper S 2008 which had few issues only. Oil leaks. AC compressor failed. Gear box will not go after 3. Talking fair. NEVER buy this crappy product. I will not pay a penny for 2015 brand new with 10 years warrant. THANKING you and hope readers will know its good if you have 2 cars and you work for the agent.

I have a MINI 2009 Clubman S. At 48000 miles, I had to replace the turbo. At 58000, I had to replace the engine for a failed timing chain. I will have put 10000 more into a car costing 28000 with 56000 miles total. Both the turbo and the timing chain gave me no warning lights from the super duper computer system I was sold on. My dealership in Memphis Tn is horrible as well. I went to one of the dealerships in North Atlanta, Wonderful service! I had been missing the passenger foot mat for all the visits to the Memphis location for years. They never replaced it. The Atlanta dealer did at no charge. I did not even ask. I am at my wits end with my dealership and this lemon of a car. I am talking to an attorney tomorrow.

2005 Mini Cooper - My first problem with my Mini was the power steering pump. The original went with less than 10,000 km. Replaced with used - it broke down very soon after. I bought one from Mini for warranty - last summer. Since then, my tranny failed. The mechanic said it had a hole in the lower left section. I bought one from a salvage company from Quebec. I replaced that one in Feb. and due to bad weather, only drove it short distances 3 or 4 times. April 23rd (90-day warranty), it broke down when I had my disabled son with me - good thing we had just gotten into London, ON. 2 weeks left on warranty, the salvager wont honor. I will go to small claims court. We managed to get to the Mini dealer. They were only going to get rid of my airbag error light. They did and told me after their scans that this automobile has numerous problems. Not once did they indicate all the problems associated with these cars. They tried to tell me that it was old. It has been OFF the road more than on in the 7 years Ive had it!! Less than 98,000 km! The horn wouldnt work so we put an aftermarket one on. My son did it and works great. One side of the hood wont catch, 3 power steering motors and pumps, and now 2 trannies!! Mister transmission will tell me tomorrow whether or not they can fix it, and if so, will give me a warranty of 100,000 kms or 5 years! I will get it fixed if not too much and then sell it or trade it if the warranty goes with the car. Gas mileage was always great, BUT it is DANGEROUS and I will NEVER RISK DRIVING WITH MY FAMILY AGAIN!! Mini would NEVER admit any of these problems and KNEW it all along!

The problems with the Mini Cooper are two-fold: 1) the design of the car is atrocious. 2) the maker & the service are designed to financially abuse the purchaser. First, the design flaws: OK, this car was designed as a toy, not as a practical piece of transportation. But why did they make the dipstick impossible to read? Why did they go out of their way to make the clock a brain twister to reset the hours (which we do twice a year in America)? Why did they make it so that putting the windows up and down while driving is actually a painful distraction from driving? Other than that, the car is small but has terrible fuel efficiency. It is too small for road trips (unless you really, really like this car), too small for carrying much more than a few groceries, and too small for anyone with children. Yet it is not a luxury sports car, and it sure isnt an economy model. The ride is nauseating. There is such turbo-lag that it is dangerous to try to pull into fast-moving traffic because your car will wait a beat or two before lurching forward. NOW, the use of this car as an instrument of financial abuse: this car is designed to take your money away from you. My wife bought it to drive to the train station and yoga on weekends (not good for anything else, really). She bought it as a Certified used car from the Mini dealer. In a year and a half, she put on 900 miles. I took it in for an oil change - and they told me I had to replace the brake fluid ($150) as well as the micro-filter ($110). Another 18 months, another 1700 miles - and THIS TIME the dealer wants us to spend more than $3,700 to fix all the little things they say are rotting off the car everywhere they look. To review, with oil changes, that is more than $4,000 in maintenance to drive a Certified car 2600 miles over 3 years. Good thing / bad thing? BAD THING! Bad bad bad car!

Ive had my 2009 Mini Cooper since, well, 2009. It was the car that I test drove on the lot, and I fell in love with it at first sight. All was great, until it wasnt. Started having problems at around the 2 year mark. Since it was still under warranty, some stuff was covered. But once the warranty was out, I had to pay out of pocket which was REALLY pricey. Finally after 5 years, I was able to find a good, honest, Mini-expert mechanic who told me my Mini would need a refill of oil every three gas fill ups! He said my model Mini burns oil every couple hundred miles. Ive also noticed that my coolant needs refilling every few weeks as well. And just today when I turned it on my window said it needed service, when yesterday the counter told me in 600 miles. I think its come to the end of the road for me and my Mini. But it will be in tears because I just love that damn car.

If I didnt like the car type, I never would have bought it. But it has been a nightmare to work with BMW on fixing something that is clearly their fault. BMW refuses to provide a satisfactory solution with a recall on a known flaw in the thermostat gasket on 2006 Mini Coopers. Thousands of consumers in United States, and even more across the world, have spent thousands of dollars and countless hours to find/fix radiator fluid leak through both dealers and special mechanics only to find out that the original gasket starts to leak through ever so slowly. A drop here and there at about 20,000 miles (more or less) due to the cheap mesh material. Because it leaks ever so slightly, the fluid falls, blows, drops down onto various parts of the engine and throughout the engine compartment. Even though the company, dealers and specialized mechanics are well aware of this known issue, they take full advantage of the consumer by pretending to speculate that it is caused by a leak in a hose or the radiator itself or some other issue, all of which allow these individuals to charge outrageous amounts to fix or replace parts that down need it. Most places have a minimum labor cost just to look at it. Add the unnecessary parts with additional labor on top of the base cost and you drive away without fixing the issue, only to return again and again until they finally bring up the real issue and charge you yet again to fix something they knew and should have fixed all along. It is a known issue for crying out loud. If they just fixed that, the parts themselves are less than $50. Add a minimal labor cost and you are still under $200 total. But no, BMW has systematically ignored the issue in an effort to sell parts, charge labor, and collect vast amounts of unnecessary dollars because it make them more money. The truth is, after the 2006 models, BMW intentionally changed the design to a poly urethane gasket. No recall, no recourse, no satisfaction! BMW should recall these or reimburse the wasted costs created by those that represent their firm. Thieves!

We should have known that it would be a mistake to purchase this car, when we were treated very rudely at the BMW dealership... but we really wanted a convertible. Biggest mistake we ever made. Less than a year old, and drivers side window motor had to be replaced. Less than a year old, and engine mount had to be replaced. 2 years old and the fuel pump had to be replaced. Multiple repairs spanning multiple years on the obviously flawed cooling system (out of warranty). At 5 years old, had to pay $7,000 for a REBUILT engine. 6 weeks after the rebuilt engine, and now the entire electrical system is gone. The dealer says its $400 just to diagnose it (and he cant get to it for a week, causing me to have to rent a car) and that he has no idea what is wrong, and has never seen anything like it.

I love Mini Cooper Countryman 2011 but the car I was driving and the steel wheel lock by self when I was exit on the freeway. Scare me. So now I don’t trust the car anymore. Pls let me know if that happen to anybody. Thanks.

60,000 and I need a new engine. Had the car 1 1/2 yrs. Mechanic told me damage was done BEFORE I bought it. Timing chain, oil, etc just like all the other complaints and Im getting the run-around. Thought BMW was a great product.... Guess not.

Mini Cooper S 2006 Convertible - New radiator and cooling system at 5k, 3 new convertible roofs due to rotting weather stripping, one rat attack, one harmonic balancer, one transmission, engine mounts, transmission mount, control arm bushings - all at 65k.

I just bought a 2009 Mini Cooper S from Carmax last week with 21,000 miles on it. I drove it less than 400 miles before the clutch became an issue. I took the car to Carmax for warranty work and was told that the dealer would have to do the service. Sure enough, the dealer stated it was not covered under warranty due to normal wear and tear. Based on all the comments Ive read on this forum, I am returning the car to Carmax for a full refund since I am not the only one with this same issue. I understand that buying a used car is a buyer beware situation, but Mini Cooper should be more responsive to a problem that exists for many owners. Mini Cooper is not building a quality product and I will never buy another Mini Cooper.

I have a 2007 Mini and it currently has 38,000 miles on it. The timing system has to be replaced which I find ridiculous considering the low mileage and how well I have taken care of it. Do not buy one of these cars - they suck!